|
Effects of feeding solid-state fermented rapeseed meal
on performance, nutrient digestibility, intestinal ecology and
intestinal morphology of broiler chickens.
|
|
|
|
|
| Abstract: | This trial was conducted to determine the effects of feeding a diet containing solid-state fermented rapeseed meal on performance, nutrient digestibility, intestinal ecology and intestinal morphology of broiler chickens. A mixed liquid culture, containing approximately 5 log cfu/ml Lactobacillus fermentum, Enterococcus faecium, Saccharomyces cerevisae and Bacillus subtilis was prepared in a 1:1:1:1 ratio. A basal substrate (BS) containing 75% rapeseed, 24% wheat bran and 1% brown sugar was mixed with the liquid culture in a ratio of 10:3. Over the 30-day fermentation, isothiocyanates were reduced from 119.6 to 14.7 mmol/kg. A total of 168, day-old male Arbor Acres broiler chicks were assigned to one of three dietary treatments including a corn-soybean meal based control diet as well as two experimental diets in which the control diet was supplemented with 10% of the BS containing unfermented rapeseed meal or 10% of the BS containing rapeseed meal subjected to solid state fermentation. There were 8 pens per treatment and 7 birds per pen. From days 19-21 and days 40-42, uncontaminated excreta were collected from each pen for digestibility determinations. In addition, digesta from the colon and ceca were collected to determine the number of lactobacilli, enterobacteria and total aerobes. The middle sections of the duodenum, jejunum, and ileum were collected for intestinal morphology. Over the entire experimental period (d 1-42), the weight gain and feed conversion of birds fed fermented rapeseed meal were superior (p<0.05) to that of birds fed nonfermented rapeseed meal and did not differ from the soybean control. On day 42, birds fed fermented rapeseed meal had higher (p<0.05) total tract apparent digestibility coefficients for dry matter, energy, and calcium than birds fed non-fermented rapeseed meal. Colon and ceca digesta from broilers fed the fermented feed had higher (p<0.05) lactobacilli counts than birds fed the control and non-fermented rapeseed meal diets on day 21 and 42. Fermentation also improved (p<0.05) villus height and the villus height:crypt depth ratio in the ileum and jejunum on day 21 and 42. The results indicate that solid-state fermentation of rapeseed meal enhanced performance and improved the intestinal morphology of broilers and may allow greater quantities of rapeseed meal to be fed to broilers potentially reducing the cost of broiler production. (Key Words : Broiler, Intestinal Morphology, Nutrient Digestibility, Microbial Characteristics, Rapeseed Meal, Solid-state Fermentation) |
|
|
|
| Article Type: | Report |
| Subject: |
Broilers (Poultry)
(Food and nutrition) Rapeseed (Nutritional aspects) Grain as feed (Research) Digestion (Research) |
| Authors: |
Chiang, G. Lu, W.Q. Piao, X.S. Hu, J.K. Gong, L.M. Thacker, P.A. |
| Pub Date: | 02/01/2010 |
| Publication: | Name: Asian - Australasian Journal of Animal Sciences Publisher: Asian - Australasian Association of Animal Production Societies Audience: Academic Format: Magazine/Journal Subject: Agricultural industry; Biological sciences Copyright: COPYRIGHT 2010 Asian - Australasian Association of Animal Production Societies ISSN: 1011-2367 |
| Issue: | Date: Feb, 2010 Source Volume: 23 Source Issue: 2 |
| Topic: | Event Code: 310 Science & research |
| Product: | Product Code: 0251000 Chickens, Broilers; 0139170 Rapeseed; 0110010 Feed Grains NAICS Code: 11232 Broilers and Other Meat Type Chicken Production; 11112 Oilseed (except Soybean) Farming; 1111 Oilseed and Grain Farming SIC Code: 2015 Poultry slaughtering and processing; 0119 Cash grains, not elsewhere classified |
| Geographic: | Geographic Scope: China Geographic Code: 9CHIN China |
| Accession Number: | 218449463 |
| Full Text: |
INTRODUCTION Soybean meal is the most commonly used source of supplementary protein for poultry and it is generally a consistent, high quality product (Britzman, 2006). Unfortunately, the cost of using soybean meal can be prohibitive and many poultry producers are looking for alternative sources of supplementary protein which may be available at a lower cost. In China, one such alternative is rapeseed meal. Rapeseed meal is a coarse powdery material, produced from rapeseed cake after a series of preparatory physical processes followed by multi-stage extraction of its oil under hygienically controlled conditions. The meal is a good source of protein for animal feeding but the presence of toxic glucosinolates limit its utilization (Bourdon and Aumaitre, 1990; Elangovan et al., 2001; Tripathi and Mishra, 2006). Glucosinolates are hydrolysed by a myrosinase enzyme present in the rapeseed to release a range of breakdown products (Mithen et al., 2000; Cheng et al., 2004). The most common products are isothiocyanates which cause reduced feed intake, impaired growth and high mortality rates (Clandinin et al., 1966; Campbell and Smith, 1979; McNeill et al., 2004). Considerable interest has recently been shown in the use of fermented feeds to improve pig performance and influence the bacterial ecology of their gastrointestinal tract (Canibe and Jensen, 2003; Canibe et al., 2008). However, this technology has not been widely applied with poultry. Since fermentation has been shown to reduce the glucosinolate content of rapeseed meal (Rozan et al., 1996; Adarsh and Amandeep, 2001; Vig et al., 2001), the use of solid-state fermentation may improve the nutritive value of rapeseed meal when it is fed to poultry. Therefore, the present study was conducted to investigate the chemical and microbial characteristics of solid-state fermented rapeseed meal during fermentation and to determine the effects of fermentation on performance, nutrient digestibility, intestinal ecology and intestinal morphology when fed to broiler chickens. MATERIALS AND METHODS A mixed liquid culture containing approximately 5 log cfu/ml Lactobacillus fermentum (CGMCC No. 0843), Enterococcus faecium (CGMCC No. 1.2025), Saccharomyces cerevisae (CGMCC No. 2.1793) and Bacillus subtilis (MA 193), was prepared in a 1:1:1:1 ratio. A basal substrate containing 75% rapeseed meal, 24% wheat bran and 1% brown sugar was mixed with the liquid culture in a 10:3 ratio. The mixture was packaged and sealed in a newly-developed multi-layer polythene bag (25 kg capacity) equipped with a one-way valve to allow the release of any carbon dioxide produced during fermentation (Rou Duoduo Biotechnology Co., Beijing, China). This technology has been patented by the State Intellectual Property Office of the Peoples Republic of China under patent number PCT/CN20061001134. During the initial stage of fermentation, Saccharomyces cerevisae yeast rapidly consumed the oxygen in the bag and produced large amounts of carbon dioxide. The gas pressure from carbon dioxide was discharged through the valve but the valve did not allow external air into the bag. This process created an anaerobic and acidic environment which provided both lactobacilli and Bacillus with optimum conditions in which to grow and reproduce. The fermentation was held at 30 [+ or -] 3[degrees]C for 30 days. Samples of the solid-state fermented feed were collected on d 0, 1, 3, 7, 12, 20, and 30 for lactobacilli counts and chemical analysis. A total of 21 bags were prepared and 3 bags were opened on each day. Bags were discarded following sampling. Lactobacilli counts and chemical analysis of solid-state fermented rapeseed meal Ten-fold dilutions of the solid-state fermented rapeseed meal were prepared in sterile physiological saline for microbial enumeration. Lactobacilli were enumerated on MRS agar plates (Oxoid Ltd., Basingstoke, Hampshire, UK) following anaerobic incubation at 37[degrees]C for 24 h. The pH value of the solid-state fermented feed was determined by weighing 20 g of feed into a 250 ml beaker and adding 200 ml of de-ionized water. pH was measured with a pocket-sized pH meter (Hanna Instruments, Woonsocket, RI). Total isothiocyanates were measured according to Choi et al. (2004). Briefly, a 10 g sample was mixed with myrosinase (Sigma, St. Louis, MO) to release isothiocyanates. Analysis of isothiocyanates was then performed on a HP 6890 gas chromatograph equipped with a HP 5873 mass-selective detector and a HP 6890 series auto-injector (Hewlett Packard, Wilmington, DE). Feeding trial The Animal Welfare Committee of China Agricultural University approved the animal care protocol for this experiment. A total of 168, day-old, male Arbor Acres broiler chicks were purchased from the Arbor Acres Poultry Breeding Company (Beijing, China). The experimental birds were assigned to one of three dietary treatments including a corn-soybean meal based control diet as well as two experimental diets in which the control diet was supplemented with 10% of the basal substrate containing unfermented rapeseed meal or 10% of the basal substrate containing rapeseed meal subjected to solid state fermentation. The fermented rapeseed diet was never prepared more than two days before feeding to prevent the high moisture feed from going moldy. The birds were housed in wire-floored pens (90x60x40 cm) in an environmentally controlled room with continuous light. There were 8 pens per treatment and 7 birds per pen. Feed and water were available ad libitum. The room temperature was maintained at 35[degrees]C for the first 3 d and was reduced 3[degrees]C weekly until reaching 24[degrees]C. A temperature of 24[degrees]C was maintained until the end of the 42 d experiment. All birds were vaccinated against Newcastle disease on d 7 and 28 and against inactivated Infectious Bursa Disease vaccine on d 14 and 21. This experiment was conducted in 2 phases consisting of a starter phase from d 1 to 21 and a finisher phase from d 22 to 42. At the end of each period (d 21 and 42), all birds and feed were weighed by pen. Daily weight gain, feed intake and feed conversion were determined from these data. Digestibility determination Chromic oxide (0.2%) was added to all diets as a digestibility marker and was fed throughout the experiment. During days 19-21 and 40-42, uncontaminated excreta (free from feathers and feed) were collected from each pen. The excreta samples from the three collections from each cage were pooled within pen, weighed, and dried at 60[degrees]C for 48 h. The dried excreta samples were ground to pass through a 40 mesh screen, mixed thoroughly, and then homogenized using a laboratory grinder (1.0-mm screen) prior to analysis. Digestibility coefficients for dry matter, energy, calcium and phosphorus as well as nitrogen retention were determined using the equations for the indicator method described by Sauer and de Lange (1992) as follows: Apparent total tract digestibility (%) = 1-(([Cr.sub.2][O.sub.3D]/[Cr.sub.2][O.sub.3E]) x ([N.sub.E]/[N.sub.D])) x 100% where [Cr.sub.2] [O.sub.3D] is the % chromic oxide in the assay diet; NE is the % nutrient in the excreta; [Cr.sub.2][O.sub.3E] is the % chromic oxide in the excreta and ND is the % nutrient in the assay diet. Collection of intestinal tissues and digesta On d 21 and 42, one bird from each pen was randomly selected and euthanized for sampling. The digesta from the colon and ceca were collected separately and immediately immersed in liquid nitrogen and stored at -80[degrees]C until needed for bacteriological analysis. The middle sections of the duodenum (10 cm away from the pyloric junction), jejunum (proximal half of the remaining small intestine), and ileum (15 cm before the ileocecal junction) were aseptically isolated, flushed with 0.9% physiological saline solution, fixed with 4% formaldehyde-phosphate buffer, and kept at 4[degrees]C until microscopic assessment of mucosal morphology. Chemical analysis Diet and excreta dry matter (AOAC, 934.01), crude protein (AOAC, 954.01), calcium (AOAC, 927.02), phosphorus (AOAC, 965.17), ether extract (AOAC, 920.39), and ash (AOAC, 942.05) content were analyzed according to AOAC (1990). Gross energy was measured by an automatic adiabatic oxygen bomb calorimeter (Model 1281, Parr, Moline, IL, USA). Chromic oxide was determined following the method of Mueller (1956). Intestinal ecology For bacterial enumeration, about 1 g of digesta from the colon or ceca was diluted 10-fold with sterile physiological saline resulting in dilutions ranging from [10.sup.-1] to [10.sup.-8]. Lactobacilli were enumerated on MRS agar (Oxoid Ltd., Basingstoke, Hampshire, UK) following anaerobic incubation at 37[degrees]C for 24 h. Enterobacteria were quantified on McConkey agar (Beijing Haidian Microbiological Culture Factory, Beijing, China) and total aerobes were cultured on Nutrient agar (Beijing Haidian Microbiological Culture Factory, Beijing, China) following aerobic incubation at 37[degrees]C for 24 h. Each dilution was determined in triplicate. The microbial enumerations are expressed as [log.sub.10] colony forming units per gram. The concentration of lactobacilli, enterobacteria and total aerobes were determined by a visual count of colonies using the best replicates from dilutions that resulted in 30 to 300 colonies. Small intestinal morphology Villus height and crypt depth were measured according to Li et al. (1990). The intestinal samples from the middle sections of the duodenum, jejunum, and ileum were prepared using conventional paraffin embedding techniques. Briefly, all small intestinal segments were immediately fixed in 10% neutral-buffered formalin, and then embedded in paraffin. Villus height and crypt depth were measured at 40 x magnification using an Olympus microscope (CK 40, Olympus Optical Company, Shenzhen, China). Measurements of villus height and crypt depth were taken only from sections where the plane of the section ran vertically from the top of villus to the base of an adjacent crypt. Values presented are means from 7 samples of villi measured from the tip to the crypt mouth and 7 associated crypts measured from the crypt mouth to the base (Xu et al., 2003). Statistical analysis Data were subjected to analysis of variance using the GLM procedure of SAS (SAS Institute, 1996). Pen was considered as the experimental unit for the performance and digestibility data while individual bird was used as the experimental unit for microbial counts and measures of intestinal morphology. Differences among treatments were separated by Duncan's multiple range test. Results were expressed as least square means and SEM. Probability values less than 0.05 were considered statistically significant. RESULTS Solid-state fermented rapeseed meal The dry matter content of the solid-state fermented rapeseed meal dropped from 67.1% to 65.0% while crude protein content was increased from 33.8% to 36.6% after the 30 d fermentation period (Table 2). pH dropped from 5.94 at the start of fermentation to 5.42 after 30 days. Over the 30 day fermentation, isothiocyanates were reduced dramatically from 119.6 to 14.7 mmol/kg. The lactobacilli count increased rapidly during the first three days of fermentation and slowly declined thereafter. These counts were maintained at about 6.5 log cfu/g for the remainder of the fermentation period (Table 2). Broiler performance The performance of the broilers is presented in Table 3. Performance did not differ among the treatment groups during the starter period while differences were noted during the finishing period. Over the entire 42 day growth trial, the weight gain of birds fed fermented rapeseed meal was superior (p<0.05) to that of birds fed unfermented rapeseed meal and did not differ from the control. Feed conversion was significantly (p<0.05) poorer for birds fed unfermented rapeseed meal compared with the control group while feed conversion for birds fed fermented rapeseed meal did not differ from the control. Total tract apparent digestibility of nutrients The results of the digestibility study are shown in Table 4. In the starter phase, the total tract apparent digestibility of dry matter and phosphorus was higher (p<0.05) for birds fed fermented rapeseed meal than unfermented rapeseed meal. Digestibility coefficients for birds fed fermented rapeseed meal did not differ from birds fed the control. During the finisher phase, the total tract apparent digestibility of dry matter, energy and calcium were significantly higher (p<0.05) for birds fed fermented rapeseed meal than unfermented rapeseed meal. Digestibility coefficients for birds fed fermented rapeseed meal were similar to those of birds fed the control with the exception of dry matter digestibility which was higher (p<0.05) for birds fed fermented rapeseed meal than the control. Intestinal ecology Microbial counts are shown in Table 5. During both the starter and finisher phase, the total numbers of lactobacilli in the colon and ceca of birds fed fermented rapeseed meal were significantly higher (p<0.05) than those of birds fed unfermented rapeseed meal or the control. The counts of total aerobes or enterobacteria did not differ due to treatment during either the starter or finisher phase. Small intestinal morphology Dietary treatment had no effect on villus height, crypt depth, and villus height to crypt depth ratio in the duodenum during either the starter or finisher phase (Table 6). In contrast, fermented rapeseed meal increased (p<0.05) villus height and villus height to crypt depth ratio in the ileum and jejunum compared with unfermented rapeseed meal during the starter phase. In addition, villus height to crypt depth ratio in the jejunum was significantly higher for birds fed fermented rapeseed meal than for birds fed the control. During the finisher phase, birds fed either fermented rapeseed meal or the control diet had higher (p<0.05) villus height in the ileum and jejunum than birds fed unfermented rapeseed meal. These birds had a significantly higher (p<0.05) villus height to crypt depth ratio in the ileum as well. No differences were found between birds fed fermented rapeseed meal and the control during the finisher phase. DISCUSSION A mixed liquid culture of Lactobacillus fermentum, Enterococcus faecium, Saccharomyces cerevisae and Bacillus subtilis was used as the inoculum in the present study. It is typically difficult to co-incubate Bacillus subtilis MA139 (which requires an aerobic environment) with Lactobacillus fermentum (which are anaerobic bacteria) in the production of fermented feed (Koneman et al., 1983). However, in the present experiment, we used a newly-patented process (State Intellectual Property Office of the Peoples Republic of China, Patent Number PCT/ CN20061001134) to facilitate the co-culture of the two bacteria. The key to the process is the use of Saccharomyces cerevisae to consume the oxygen inside the bag to enhance a better environment for anaerobes including lactobacilli. The specially developed fermenting bag (Rou Duoduo Biotechnology Co., Beijing, China), which is equipped with a one-way valve, functioned in regulating the concentration of carbon dioxide metabolized by the aerobic strains of bacteria. The Bacillus subtilis used has been shown to be useful in decreasing the counts of enterobacteria shed in the feces of piglets (Guo et al., 2006). The Lactobacillus fermentum and Enterococcus faecium used in the present experiment have been previously shown to prevent diarrhea in E. coli challenged piglets (Huang et al., 2004). The counts of total lactobacilli (6.89 log cfu/g) obtained in the solid-state fermented rapeseed meal obtained in this study were much lower than those obtained with fermented liquid feed, which can reach as high as 9.0-9.4 log cfu/g (van Winsen et al., 2001; Canibe and Jensen, 2003; Canibe et al., 2006; Canibe et al., 2008). The lower numbers of lactobacilli may be caused by the lower water content of the solid-state fermented feed as the feed to water ratio used was just 10:3 while feed to water ratios of 1:2 to 1:2.75 have been reported with fermented liquid feed (van Winsen et al., 2001; Canibe and Jensen, 2003; Canibe et al., 2006; Canibe et al., 2008). The decline in the dry matter content of the solid-state fermentation feed (3.1 percentage units) was most likely caused by the consumption of carbohydrate by yeast and aerobic bacteria. The absence of oxygen during the later stages of the fermentation would impair the growth and metabolism of yeast thus explaining the fact that the dry matter content reached a plateau after about 12 days of fermentation. The crude protein concentration increased slightly (2.8 percentage units) and this increase is most likely a reflection of the decline in dry matter content rather than an actual increase in protein content. The decrease in pH from 5.94 to 5.42 which occurred during fermentation was most likely the result of the increased concentration of organic acids produced by the increased numbers of lactobacilli (van Winsen et al., 2000; Canibe et al., 2006; Canibe et al., 2008). The most significant effect of the solid-state fermentation was the dramatic reduction in the isothiocyanate content in the rapeseed meal which declined by over 90%, and this result was comparable with that obtained with fermented cottonseed meal where the antinutritional factor gossypol was reduced by solid state fermentation (Zhang et al., 2007). The decomposition of isothiocyanates increased as the duration of the fermentation period increased and this result was similar to the study of Vig and Walia (2001). The reduction in isothiocyanates during fermentation may be due to utilization of glucose and the sulphur moieties of these compounds by microbial enzymes (Vig and Walia, 2001; Tripathi and Mishra, 2006). Feeding rapeseed meal to broilers typically causes reduced feed intake, impaired growth, and high mortality rates compared with feeding soybean meal (Clandinin et al., 1966; Campbell and Smith, 1979; McNeill et al., 2004). Our results support this earlier work as birds fed the diet containing unfermented rapeseed meal had poorer weight gain and feed conversion than birds fed the soybean meal control. In contrast, the performance of birds fed fermented rapeseed meal was similar to that of the control likely reflecting the reduction in isothiocyanates in the fermented feed. The improved nutrient digestibility (dry matter, energy and calcium) of the diets containing fermented rapeseed meal compared with unfermented rapeseed meal resulted in improved broiler performance. A beneficial effect of fermentation on nutrient digestibility and energy utilization has been shown previously in mink and salmon (Skrede et al., 2001; Skrede et al., 2002). Lactobacilli have the ability to inhibit the growth of putrefactive and pathogenic bacteria (Paton et al., 2006). In the current study, inclusion of fermented rapeseed meal successfully enhanced the growth of lactobacilli in the colon and ceca compared with either the control diet or the unfermented rapeseed meal diet. In agreement with our findings, van Winsen et al. (2001) and Canibe and Jensen (2003) indicated that supplementation with fermented feed increased the gastrointestinal lactobacilli population. All these data suggest that fermented feed may act in a similar manner to probiotics to improve gastrointestinal health (Paton et al., 2006). A balanced microbial population would support a healthy intestinal tract resulting in better control of intestinal pathogens. The villus height to crypt depth ratio is a very useful measure to estimate the absorption capacity of the small intestine (Montagne et al., 2004). Maximum digestion and absorption is believed to occur as the villus height to crypt depth ratio increases in weaned pigs (Pluske et al., 1996). Changes in the intestinal morphology such as reduced villus height and deeper crypt may also indicate the presence of toxins (Xu et al., 2003). In the present study, increased villus height and increased villus height to crypt depth ratio in the ileum and jejunum were observed in broilers supplemented with fermented rapeseed meal compared with unfermented meal. The increased villus height and villus height to crypt depth ratio might be associated with the increased numbers of beneficial bacteria (lactobacilli) observed (Xu et al., 2003). The increased villus height to crypt depth ratio produced an intestinal structure more oriented to digestion, with improved absorptive and hydrolysis potential, as well as requiring fewer nutrients to be directed towards intestinal maintenance (Pluske et al., 1996). Thus, with fermented rapeseed, the intestinal structure of the ileum and jejunum is more favorable for the bird and may help to explain the improvement in weight gain and feed conversion observed during the finisher phase. In conclusion, solid-state fermentation of rapeseed meal significantly reduced the isothiocyanate content of the rapeseed meal. As a result, broiler performance was significantly improved compared with birds fed unfermented rapeseed meal and was similar to the performance obtained with broilers fed soybean meal. Compared with unfermented rapeseed meal, solid-state fermentation improved nutrient digestibility, increased the numbers of lactobacilli in the colon and ceca and enhanced the small intestinal structure of the broilers. Solid-state fermentation of rapeseed meal may allow greater quantities of rapeseed meal to be fed to broilers potentially reducing the cost of broiler production. ACKNOWLEDGMENTS This investigation was financially supported by the Ministry of Science and Technology of the People's Republic of China (2006BAD12B07-2). REFERENCES Adarsh, P. V. and W. Amandeep. 2001. Beneficial effects of Rhizopus oligosporus fermentation on reduction of glucosinolates, fibre and phytic acid in rapeseed (Brassica napus) meal. Bioresour. Technol. 78:309-312. AOAC. 1990. Official methods of analysis. 16th ed. Association of Official Analytical Chemists, Washington, DC. Bourdon, D. and A. Aumaitre. 1990. Low glucosinolate rapeseed and rapeseed meal: Effect of technological treatments on chemical composition, digestible energy content and feeding value for growing pigs. Anim. Feed Sci. Technol. 30:175-191. Britzman, D. G. 2006. Soybean meal: An excellent protein source for poultry feeds. American Soybean Association Technical Bulletin. Available at http://www.asa-europe.org.pdf/Britzman.pdf (Last accessed Nov 20, 2008). Campbell, L. D. and T. K. Smith. 1979. Response of growing chicks to high dietary content of rapeseed meal. Br. Poult. Sci. 20:231-237. Canibe, N. and B. B. Jensen. 2003. Fermented and non-fermented liquid feed to growing pigs: Effect on aspects of gastrointestinal ecology and growth performance. J. Anim. Sci. 81:2019-2031. Canibe, N., E. Virtanen and B. B. Jensen. 2006. Microbial and nutritional characteristics of pig liquid feed during fermentation. Anim. Feed Sci. Technol. 134:108-123. Canibe, N., H. Miettinen and B. B. Jensen. 2008. Effect of adding Lactobacillus plantarum or a formic acid containing product to fermented liquid feed on gastrointestinal ecology and growth performance of piglets. Livest. Sci. 144:251-262. Cheng, D. L., K. Hosimoto and Y. Uda. 2004. In vitro digestion of sinigrin and glucotropeolin by single strain of Bifidobacterium and identification of digestive products. Food Chem. Toxicol. 42:351-357. Choi, M. M. F., S. S. Shuang, H. Y. Lai, S. C. Cheng, R. C. W. Cheng, B. K. B. Cheung and W. M. Lee. 2004. Gas chromatography-mass spectrometric determination of total isothiocyanates in Chinese medicinal herbs. Anal. Chem. Acta. 516:155-163. Clandinin, D. R., L. Bayley and A. Camballero. 1966. Effect of ([+ or -])-5-vinyl-2-oxazolididinethione-A toxic content in rapeseed meal, on the rate of growth and thyroid function of chicks. Poult. Sci. 45:833-838. Elangovan, A. V. S., V. S. Verma, V. R. B. Sastry and S. D. Singh. 2001. Effect of feeding high glucosinolate rapeseed meal to laying Japanese Quail. Asian-Aust. J. Anim. Sci. 14:1304-1307. Guo, X. H., D. F. Li, W. Q. Lu, X. S. Piao and X. L. Chen. 2006. Screening of Bacillus strains as potential probiotics and subsequent confirmation of the in vivo effectiveness of Chiang et al. (2010) Asian-Aust. J. Anim. Sci. 23(2):263-271 Bacillus subtilis MA139 in pigs. Int. J. Gener. Mol. Microbiol. 90:139-146. Huang, C., S. Qiao, D. Li, X. Piao and J. Ren. 2004. Effects of lactobacilli on the performance, diarrhea incidence, VFA concentration and gastrointestinal microbial flora of weaning pigs. Asian-Aust. J. Anim. Sci. 17:401-409. Koneman, E. W., S. D. Allen, V. R. Dowell, Jr. and H. M. Sommers. 1983. Color atlas and textbook of diagnostic microbiology. 2nd Ed. J. B. Lippincott Company. Philadelphia, PA. pp. 348-349. Li, D. F., R. C. Thaler, J. L. Nelssen, D. L. Harmon, G. L. Allee and T. L. Weeden. 1990. Effects of fat sources and combinations on starter pig performance, nutrient digestibility and intestinal morphology. J. Anim. Sci. 68:3694-3704. McNeill, L., K. Bernard and M. G. MacLeod. 2004. Food intake, growth rate, food conversion and food choice in broilers fed on diets high in rapeseed meal and pea meal with observations of the resulting poultry meat. Br. Poult. Sci. 45:519-523. Mieke, T. 2007. Oil World Annual. ISTA. Mielk GmbH, Hamburg, Germany. Mithen, R. F., M. Dekker, R. Verkerk, S. Rabot and I. T. Johnson. 2000. The nutritional significance, biosynthesis and bioavailability of glucosinolates in human foods. J. Sci. Food Agric. 80:967-984. Mueller, W. 1956. Feasibility of the chromic oxide and lignin indicator methods for metabolism experiments with chickens. J. Nutr. 58:29-36. NRC. 1994. Nutrient requirements of poultry. 9th rev. ed. National Academy Press, Washington, DC. Paton, A. W., R. Morona and J. C. Paton. 2006. Designer probiotics for prevention of enteric infections. Nat. Rev. Microbiol. 4:193-200. Pluske, J. R., M. J. Thompson, C. S. Atwood, P. H. Bird, L. H. Williams and P. E. Hartmenn. 1996. Maintenance of villus height and crypt depth, and enhancement of disaccharide digestion and monosaccharide absorption, in piglets fed on cows' whole milk after weaning. Br. J. Nutr. 76:409-422. Rozan, P., C. Villaume, H. M. Bau, A. Schwert, J. P. Nicolas and I. Mejean. 1996. Detoxification of rapeseed meal by Rhizopus oligosporus sp. T3: A first step towards rapeseed protein concentrate. Ind. J. Food Sci. Technol. 31:85-90. SAS Institute. 1996. SAS user's guide: Statistics. Version 7.0. SAS Institute, Cary, NC. Sauer, W. C. and K. de Lange. 1992. Novel methods for determining protein and amino acid digestibilities in feedstuffs. In: Modern methods in protein nutrition and metabolism (Ed. S. Nissen). Academic Press Inc., San Diego, CA. pp. 87-120. Skrede, G., S. Sahlstrom, A. Skrede, A. Holck and E. Slinde. 2001. Lactic acid fermentation of wheat and barley whole meal flour modifies carbohydrate composition and increases digestibility in mink (Mustela vison). Anim. Feed Sci. Technol. 90:199-212. Skrede, G., T. Storebakken, A. Skrede, S. Sahlstrom, M. Sorensen, K. D. Shearer and E. Slinde. 2002. Lactic acid fermentation of wheat and barley whole meal flours improves digestibility of nutrients and energy in Atlantic salmon (Salmo salar L.) diets. Aquaculture 210:305-321. Tripathi, M. K. and A. S. Mishra. 2006. Glucosinolates in animal nutrition: A review. Anim. Feed Sci. Technol. 132:1-27. van Winsen, R. L., B. A. P. Urlings, L. J. A. Lipman, J. M. A. Snijders, D. Keuzenkamp, J. H. M. Verheijden and F. van Knapen. 2001. Effect of fermented feed on the microbial population of the gastrointestinal tracts of pigs. Appl. Environ. Microbiol. 67:3071-3076. Vig, A. P. and A. Walia. 2001. Beneficial effects of Rhizopus oligosporus fermentation on reduction of glucosinolates, fiber and phytic acid in rapeseed (Brassica napus) meal. Bioresour. Technol. 78:309-312. Xu, Z. R., C. H. Hu, M. S. Xia, X. A. Zhan and M. Q. Wang. 2003. Effects of dietary fructooligosaccharide on digestive enzyme activities, intestinal microflora and morphology of male broilers. Poult. Sci. 82:648-654. Zhang, W., Z. Xu, J. Sun and X. Yang. 2006. A study on the reduction of gossypol levels by mixed culture solid substrate fermentation of cottonseed meal. Asian-Aust. J. Anim. Sci. 19:1314-1321. G. Chiang, W. Q. Lu *, X. S. Piao, J. K. Hu, L. M. Gong and P. A. Thacker (1) College of Animal Science and Technology, China Agricultural University, Yuanmingyuan West Road, Beijing, Post Code 100193, China * Corresponding Author: W. Q. Lu. Tel: +86-10-6273-3588, Fax: +86-10-6273-3688, E-mail: luwq@mafic.ac.cn (1) Department of Animal and Poultry Science, University of Saskatchewan, 51 Campus Drive, Saskatoon, Saskatchewan, S7N 5A8, Canada Received March 2, 2009; Accepted May 4, 2009 Table 1. Ingredient composition and nutrient content of experimental
diets containing solid-state fermented rapeseed meal
Starter phase (d 1 to 21)
Items Control Unfermented Fermented
rapeseed rapeseed
meal meal
Ingredients (% as-fed)
Corn 55.89 50.87 50.87
Soybean meal (43% CP) 33.35 26.20 26.20
Fermented rapeseed meal 0.00 0.00 10.00
Unfermented rapeseed meal 0.00 10.00 0.00
Fish meal (64% CP) 4.50 4.50 4.50
Soybean oil 1.86 3.40 3.40
Limestone 1.27 0.88 0.88
Dicalcium phosphate 1.23 1.94 1.94
Premix (1) 1.00 1.00 1.00
Salt 0.30 0.30 0.30
Chromic oxide 0.20 0.20 0.20
L-lysine-HCl (78%) 0.01 0.27 0.27
DL-methionine (98%) 0.19 0.24 0.24
Nutrient content (2)
ME (Mcal/kg) 2.90 2.90 2.90
Crude protein 22.71 22.44 22.76
Calcium 1.02 1.03 1.00
Total phosphorus 0.79 0.85 0.82
Ether extract 4.89 6.31 6.21
Ash 7.21 7.85 7.93
Lysine 1.28 1.28 1.28
Methionine 0.58 0.58 0.58
Finisher phase (d 22 to 42)
Items Control Unfermented Fermented
rapeseed rapeseed
meal meal
Ingredients (% as-fed)
Corn 59.76 54.73 54.73
Soybean meal (43% CP) 30.18 23.03 23.03
Fermented rapeseed meal 0.00 0.00 10.00
Unfermented rapeseed meal 0.00 10.00 0.00
Fish meal (64% CP) 3.00 3.00 3.00
Soybean oil 2.82 4.34 4.34
Limestone 1.20 0.85 0.85
Dicalcium phosphate 1.15 1.85 1.85
Premix (1) 1.00 1.00 1.00
Salt 0.35 0.35 0.35
Chromic oxide 0.20 0.20 0.20
L-lysine-HCl (78%) 0.04 0.30 0.30
DL-methionine (98%) 0.10 0.15 0.15
Nutrient content (2)
ME (Mcal/kg) 3.00 3.00 3.00
Crude protein 20.83 20.67 20.72
Calcium 0.92 0.88 0.93
Total phosphorus 0.70 0.72 0.76
Ether extract 5.92 7.21 7.15
Ash 5.72 6.12 6.07
Lysine 1.15 1.15 1.15
Methionine 0.45 0.45 0.45
(1) The premix provided the following (per kilogram of compound
feed): zinc, 60 mg; iron, 95 mg; manganese, 80 mg; copper, 10 mg;
iodine, 0.35 mg; selenium, 0.3 mg; vitamin A, 10,000 IU; vitamin
[D.sub.3], 2,750 IU; vitamin E, 30 IU; vitamin [K.sub.3], 2 mg;
vitamin [B.sub.12], 12 [micro]g; riboflavin, 6 mg; nicotinic acid,
40 mg; pantothenic acid, 12 mg; pyridoxine, 3 mg; biotin, 0.2 mg;
choline chloride, 800 mg.
(2) Crude protein, calcium, phosphorus, ether extract, and ash are
analyzed values. The metabolizable energy and amino acid content
were calculated.
Table 2. Characteristics of solid-state fermented rapeseed meal
during fermentation
Time (d) Dry matter (%) pH Crude
protein (%)
0 67.1 5.94 33.8
1 66.5 5.91 34.0
3 63.5 5.64 34.6
7 66.1 5.58 35.2
12 64.2 5.47 36.1
20 63.8 5.47 36.3
30 64.0 5.42 36.6
Time (d) Lactobacilli Isothiocyanates
(log cfu/g) (mmol/kg)
0 4.05 119.6
1 4.34 99.5
3 6.89 37.9
7 6.82 35.1
12 6.70 27.9
20 6.54 20.6
30 6.41 14.7
Table 3. Effects of solid-state fermented rapeseed meal on the
performance of broilers (d 1-42)
Items (1) Control Unfermented Fermented
rapeseed rapeseed
meal meal
Days 1 to 21
Weight gain (g/d) 34.2 32.8 34.7
Feed intake (g/d) 45.1 46.1 46.6
Feed conversion 1.32 1.40 1.34
Days 22 to 42
Weight gain (g/d) 73.8 (a) 67.3 (b) 72.5 (a)
Feed intake (g/d) 120.6 115.9 121.2
Feed conversion 1.63 (b) 1.72 (a) 1.67 (ab)
Days 1 to 42
Weight gain (g/d) 53.9 (a) 50.2 (b) 53.6 (a)
Feed intake (g/d) 82.6 80.6 84.1
Feed conversion 1.54 (b) 1.62 (a) 1.57 (ab)
Items (1) SEM p-value
Days 1 to 21
Weight gain (g/d) 0.70 0.55
Feed intake (g/d) 0.51 0.19
Feed conversion 0.03 0.19
Days 22 to 42
Weight gain (g/d) 0.77 0.05
Feed intake (g/d) 1.03 0.06
Feed conversion 0.02 0.05
Days 1 to 42
Weight gain (g/d) 0.70 0.05
Feed intake (g/d) 0.59 0.09
Feed conversion 0.01 0.05
(a, b) Means in the same row with no common superscripts differ
significantly (p<0.05). Data were means of 8 pens of birds.
Table 4. Effects of solid-state fermented rapeseed meal on total
tract apparent nutrient digestibility (%) in broilers determined
on day 21 and 42
Diet
Items Control Unfermented Fermented
rapeseed meal rapeseed meal
Day 21
Dry matter 77.7 (a) 72.9 (b) 77.4 (a)
Energy 79.9 77.6 82.7
Calcium 57.0 56.8 58.0
Phosphorus 58.2 (ab) 49.4 (b) 60.2 (a)
Nitrogen retention 65.7 68.3 69.1
Day 42
Dry matter 71.5 (b) 68.1 (b) 75.8 (a)
Energy 79.3 (ab) 76.2 (b) 82.7 (a)
Calcium 56.3 (a) 43.3 (b) 50.6 (a)
Phosphorus 48.2 47.2 49.1
Nitrogen retention 58.0 54.5 57.9
Items SEM p-value
Day 21
Dry matter 0.83 0.05
Energy 0.64 0.12
Calcium 1.22 0.91
Phosphorus 1.93 0.05
Nitrogen retention 1.12 0.45
Day 42
Dry matter 1.02 0.05
Energy 1.01 0.05
Calcium 1.63 0.05
Phosphorus 1.28 0.86
Nitrogen retention 1.77 0.69
(a, b) Means in the same row with no common superscripts differ
significantly (p<0.05). Data were means of 8 birds per treatment.
Table 5. Microbial counts of lactobacilli, enterobacteria, and total
aerobes in the colon and ceca digesta (log cfu/g) of broilers fed
different dietary treatments
Diet
Control Unfermented Fermented
rapeseed rapeseed
meal meal
Day 21
Colon
Lactobacilli 5.33 (c) 6.38 (b) 7.61 (a)
Enterobacteria 4.10 4.78 4.05
Total aerobes 5.58 5.32 5.74
Ceca
Lactobacilli 5.88 (b) 6.53 (b) 7.88 (a)
Enterobacteria 4.38 5.27 4.86
Total aerobes 6.07 6.40 6.37
Day 42
Colon
Lactobacilli 6.27 (b) 5.82 (b) 7.93 (a)
Enterobacteria 4.13 4.88 3.61
Total aerobes 6.03 5.68 6.17
Ceca
Lactobacilli 6.78 (b) 7.12 (b) 8.66 (a)
Enterobacteria 5.55 5.09 5.06
Total aerobes 6.77 6.74 5.96
SEM p-value
Day 21
Colon
Lactobacilli 0.31 0.05
Enterobacteria 0.16 0.11
Total aerobes 0.15 0.53
Ceca
Lactobacilli 0.30 0.05
Enterobacteria 0.19 0.18
Total aerobes 0.14 0.64
Day 42
Colon
Lactobacilli 0.38 0.05
Enterobacteria 0.39 0.43
Total aerobes 0.15 0.45
Ceca
Lactobacilli 0.35 0.05
Enterobacteria 0.30 0.80
Total aerobes 0.22 0.25
(a-c) Means in the same row with no common superscripts differ
significantly (p<0.05). Data were means of 8 birds per treatment.
Table 6. Effects of solid-state fermented feed on small intestinal
morphology
Diet
Items Control Unfermented Fermented
rapeseed rapeseed
meal meal
Day 21
Villus height ([micro]m)
Duodenum 1,473 1,360 1,513
Jejunum 1,047 (ab) 958 (b) 1,133 (a)
Ileum 486 (a) 419 (b) 500 (a)
Crypt depth ([micro]m)
Duodenum 203 192 212
Jejunum 170 160 145
Ileum 139 155 125
Villus height/crypt depth
ratio
Duodenum 7.3 6.9 7.6
Jejunum 6.2 (b) 6.1 (b) 7.9 (a)
Ileum 3.5 (ab) 2.7 (b) 4.2 (a)
Day 42
Villus height ([micro]m)
Duodenum 1,515 1,474 1,644
Jejunum 1,247 (ab) 1,158 (b) 1,371 (a)
Ileum 575 (ab) 537 (b) 613 (a)
Crypt depth ([micro]m)
Duodenum 119 107 130
Jejunum 125 114 114
Ileum 109 125 107
Villus height/crypt depth
ratio
Duodenum 14.1 15.0 13.2
Jejunum 10.1 10.3 12.2
Ileum 5.3 (a) 4.3 (b) 5.8 (a)
Items SEM p-value
Day 21
Villus height ([micro]m)
Duodenum 33.49 0.13
Jejunum 27.08 0.05
Ileum 13.93 0.05
Crypt depth ([micro]m)
Duodenum 5.09 0.28
Jejunum 4.86 0.11
Ileum 5.38 0.08
Villus height/crypt depth
ratio
Duodenum 0.15 0.35
Jejunum 0.28 0.05
Ileum 0.22 0.05
Day 42
Villus height ([micro]m)
Duodenum 36.75 0.14
Jejunum 33.91 0.05
Ileum 13.08 0.05
Crypt depth ([micro]m)
Duodenum 8.20 0.54
Jejunum 3.47 0.37
Ileum 3.38 0.13
Villus height/crypt depth
ratio
Duodenum 1.01 0.81
Jejunum 0.41 0.07
Ileum 0.20 0.05
(a, b) Means in the same row with no common superscripts differ
significantly (p<0.05). Data were means of 8 birds per treatment. |
| Gale Copyright: | Copyright 2010 Gale, Cengage Learning. All rights reserved. |